Brumby Manual V Electronic Dizzy

Having issues with your ride ? Ask away in here ...
Post Reply
User avatar
Wooster
Junior Member
Posts: 185
Joined: Tue Dec 20, 2011 6:35 am
Location: Woolgoolga NSW

Brumby Manual V Electronic Dizzy

Post by Wooster » Wed Feb 01, 2012 3:15 pm

OK, gurus input appreciated

I decided to fit an electronic dizzy from a brumby(same model) to my 89 Brumby. I thought the process would be quite straight forward,...But!!!

With the electronic dizzy installed, she will start, but dies under revs.

The timing is spot on, the coil is brand new, the coil is fitted to a ballast, after much fiddling remove the electronic dizzy, refit the manual (points) dizzy and away she goes! I've attempted the change over twice with 2 electronic dizzy's , same outcome!!

I must be missing something & something in front of my eyes

(no wonder I shave my head otherwise I'd be tearing hair out)

Cheers

Ray

User avatar
Brumby Kid
General Member
Posts: 1297
Joined: Sun Jul 17, 2011 9:19 pm
Location: Belair S.A.

Post by Brumby Kid » Wed Feb 01, 2012 4:00 pm

Did you put the dizzy in correctly?
Here is a how to by SilverBullet....

Yes you can't just put the dizzy back on in any old fashion, the gear on the dizzy needs to be in exactly the right tooth of the gear on the crankshaft.

I think what I did last time was pull the spark plugs out and the rubber plug out of the inspection hole on flywheel housing. Turn the engine over by hand until the 0 mark appears and lines up with the pointer (I'm not sure if you have to put the pointer at -8 here, someone will confirm/deny) Then on the dizzy point the rotor at where the #1 lead goes on the dizzy cap. You have to then turn the rotor a tiny bit clockwise (I think it's clockwise) and slide the dizzy into the hole on the block. The slight clockwise turn is because when the helical gear on the dizzy slides into the teeth on the crankshaft it will turn anticlockwise slightly and would usually put your timing 1 tooth out (if you turn it slightly before it will still turn anticlockwise but you'll be on the right tooth)

Then set your timing as normal with a timing light.


Cheers Cam
When life gives you a corner, drop a gear, pitch, and stomp the loud pedal
Bianca: 1991 Subaru Brumby
My First / Project car

EA81 Rebuilt by Tony Knight from knight Engines
2" body lift
25" 185r14 Yokahama Delivery Star, light truck tyres
2" Sports exhaust
Rear Aguip step/bar
Liberty seats
"Bianca"
[SIGPIC][/SIGPIC]
Dads Car: 02 Impreza WRX STi
Mums Car 08 Liberty Wagon

User avatar
Wooster
Junior Member
Posts: 185
Joined: Tue Dec 20, 2011 6:35 am
Location: Woolgoolga NSW

Post by Wooster » Wed Feb 01, 2012 4:26 pm

Yes mate followed the process

User avatar
Brumby Kid
General Member
Posts: 1297
Joined: Sun Jul 17, 2011 9:19 pm
Location: Belair S.A.

Post by Brumby Kid » Wed Feb 01, 2012 4:34 pm

Ok,
Has to be electric as it works with the points dizzy, (would have said fuel)
Got me stumped
When life gives you a corner, drop a gear, pitch, and stomp the loud pedal
Bianca: 1991 Subaru Brumby
My First / Project car

EA81 Rebuilt by Tony Knight from knight Engines
2" body lift
25" 185r14 Yokahama Delivery Star, light truck tyres
2" Sports exhaust
Rear Aguip step/bar
Liberty seats
"Bianca"
[SIGPIC][/SIGPIC]
Dads Car: 02 Impreza WRX STi
Mums Car 08 Liberty Wagon

User avatar
Venom
General Member
Posts: 1044
Joined: Sun Feb 03, 2008 10:04 am
Location: Ballarat

Post by Venom » Wed Feb 01, 2012 6:20 pm

Have you tried rotating the dizzy 180 degrees? Flywheel rotates twice for each turn of dizzy so it can look alinged and be way out. When it is it will fire but won't run.

Sent from my GT-I9100T using Tapatalk
[SIGPIC][/SIGPIC]

User avatar
El_Freddo
Master Member
Posts: 12628
Joined: Tue Oct 04, 2005 10:00 am
Location: Bridgewater Vic
Contact:

Post by El_Freddo » Wed Feb 01, 2012 6:54 pm

Wooster wrote:With the electronic dizzy installed, she will start, but dies under revs.

The timing is spot on, the coil is brand new, the coil is fitted to a ballast
I'm pretty sure you don't use the ballast with the electronic dizzy.

It could also be the module inside the dizzy breaking down, these will cause small misses initially then break down exponentially from there until they're dead.

Yours could be damaged by the ballast - maybe, I don't know, just a guess.

Cheers

Bennie
"The lounge room is not a workshop..."
Image
El Freddo's Pics - El_Freddo's youtube

User avatar
littlewhiteute
Junior Member
Posts: 623
Joined: Sat Sep 30, 2006 7:22 am
Location: Brisbane

Post by littlewhiteute » Wed Feb 01, 2012 8:02 pm

No Ballast resistor required for electronic ignition.
Regards

Gary ;)

User avatar
Wooster
Junior Member
Posts: 185
Joined: Tue Dec 20, 2011 6:35 am
Location: Woolgoolga NSW

Post by Wooster » Thu Feb 02, 2012 7:12 am

Thanks guys, I'll have a bo-peep at removing the ballast resistor, I suppose that should be straight forward?

User avatar
RSR 555
Elder Member
Posts: 6951
Joined: Sat Nov 10, 2007 10:42 am
Location: ATM... stuck in Rockingham

Post by RSR 555 » Sat Feb 04, 2012 3:18 pm

El_Freddo wrote:I'm pretty sure you don't use the ballast with the electronic dizzy.
littlewhiteute wrote:No Ballast resistor required for electronic ignition.
Yes I concur, no ballast resistor is needed. It's only there in the points system to help reduce the arcing burn caused when the points crack open.
Wooster wrote:Thanks guys, I'll have a bo-peep at removing the ballast resistor, I suppose that should be straight forward?
Yes mate, just make sure it's 12v positive ignition feed and not accessories 12v positive feed but this should be already at your old wiring.
You know you are getting old when the candles on your birthday cake start to cost more than the cake itself.

RSR Performance
Home of the 'MURTAYA' in Oz
Subaru Impreza WRX based Sportscar
[SIGPIC][/SIGPIC]

Disclaimer: Not my website but hyperlink here to Subaru workshop manuals

User avatar
scoobymine
Junior Member
Posts: 170
Joined: Wed Dec 24, 2008 3:52 pm
Location: Vasse W.A

Post by scoobymine » Sat Feb 04, 2012 5:57 pm

When i did mine, absolutely no problem. It started first pop. The guy i bought it off gave me the coil as well, he said i couldn't use the old one as it wasn't right for electonic ignition.

User avatar
Wooster
Junior Member
Posts: 185
Joined: Tue Dec 20, 2011 6:35 am
Location: Woolgoolga NSW

Post by Wooster » Fri Mar 02, 2012 9:56 am

Bought a new coil, wired it in with the electronic dizzy, still no go, one more try. PS is there a trick to ensuring the replacement pointless dizzy is sitting correctly so it fires at the appropriate point in rotation?

User avatar
littlewhiteute
Junior Member
Posts: 623
Joined: Sat Sep 30, 2006 7:22 am
Location: Brisbane

Post by littlewhiteute » Fri Mar 02, 2012 8:20 pm

Take NO. 1 spark plug out, turn the engine with your finger over the plug hole, when you feel compression keep turning to 8 degrees BTDC on the flywheel marks.

Look at the distributor position, (rotor where it is pointing in relation to the leads) and the reluctor pickup.
The pickup should be lined on it's edges with the reluctor wheel.
Turn the dizzy to line up, or remove and refit to time the engine correctly.

Any engine should be easy enough to time with a static method prior to firing it up.
Regards

Gary ;)

User avatar
Tweety
General Member
Posts: 1253
Joined: Mon Jul 04, 2011 9:45 am
Location: ea81 powered trike Victoria

Post by Tweety » Sat Mar 03, 2012 9:01 am

Confirming with my mates above= EI no ballast on mine.

I upgraded to a MS blaster 2 coil ($100 at Autobarn)- worth it, also iridium plugs (1.1mm) and 8.8mm leads.
[SIGPIC][/SIGPIC]Tweety trike- EA81 (full reco 2014) 32/36 weber, SPFI manifold, 9.5:1 CR, VW auto.

User avatar
revmax
Junior Member
Posts: 706
Joined: Tue Dec 28, 2010 3:42 pm
Location: Coffs Harbour

Post by revmax » Sun Mar 04, 2012 6:49 am

Ray is there any spark at all.
"THE BRUMBY ! , Your not taking the Brumby I just dry cleaned the mud flaps."
Current
00 Outback with class, SOHC EJ25 auto 240,068ks
"B1" 90 Brumby with character 271,800K EA81 (But soon 5speed,103,000k EJ202)
"B2" wrecked and crushed
"B3" 89 Bush Bashing Brumby (BeeRumBee) Kept a Bucca
"B4" 89 Black Brumby (wam balam ) Kept at Kempsey
"B5" 92 Brumby (sold it)
"B6" 88 Beige Brumby
"W1" 83 wagon 308,000 AC and alot of rust repairs. (Wanda)
Brumby Trailer (Sulky)
LUV THAT BRUM !
RevMax Hobbies

[SIGPIC][/SIGPIC]

User avatar
steptoe
Master Member
Posts: 11582
Joined: Thu Oct 06, 2005 10:00 am
Location: 14 miles outside Gotham City

Post by steptoe » Sun Mar 04, 2012 7:31 am

El_Freddo wrote:
It could also be the module inside the dizzy breaking down, these will cause small misses initially then break down exponentially from there until they're dead.

Bennie

I was also experiencing the very slight, odd full stumble, rather than a miss (which is sort of suggestive of just a cylinder dropping out) in the weeks prior to my last module leaving me stranded

If it starts and idles it is not out by 180 degrees, surely?

Yep, no ballast resistor as these are to reduce the 12V IGN to about 8 or 9 Volts for points coil, EI dizzy coil needs its 12V. My Diamond ? brand genuine coils state to be used with electronic ignition

User avatar
fredsub
Junior Member
Posts: 947
Joined: Fri Oct 14, 2005 10:00 am
Location: the gong

Post by fredsub » Sun Mar 04, 2012 9:13 am

been a while since had a car with points. Isn't the ballast resistor only in the
circuit during engine start ?
The resistor being there drops the voltage, because if the engine is sitting at a position with the points closed, current is going through the coil, and otherwise the coil would burn up.

Its important to note, that with the electronic ignition, if the engine is sitting
in the same equivalent position as points closed, and ignition ON, the module itself electronically switches off the current internally. ie the "dwell" is electronically controlled. This is why the electronic dizzy never needs a ballast resistor.

Post Reply

Return to “Trouble Shooting”